TM-55-1425-289-14

CARRIER, AIR DEFENSE, MISSILE SYSTEM, XM1058 TRUCK TRANSPORTER; SHOP EQUIPMENT, GUIDED MISSILE SYSTEM; GUIDED MISSILE, AERIAL, XMIM-115 AND SHELTER CARRIER, TRUCK, CARGO, 2-1/2-TON, M35A2

TECHNICAL MANUAL; TRANSPORTABILITY GUIDANCE, ROLAND MISSILE SYSTEM AND ROLAND FIRE UNITS

SEPTEMBER 1985
TM-55-1425-289-14

  TM-55-1425-289-14 - Page 26 of 61

TM 55-1425-289-14
Table 4-5.
Tiedown Data forM35 Truck in C-141B
Aircraft (Fig 4-5)
Tiedown Fitting
Tiedown Device
Capacity
Capacity
Desig-
in
in
nation
1,000 lb
Type
1,000 lb
Attach to Item
C1
10
MB-1
10
Bumperette, left side.
El
10
MB-1
10
Bumperette, right side.
C2
10
MB-1
10
Rear axle, left side.
E2
10
MB-1
10
Rear axle, right side.
B3
10
MB-1
10
Front axle, right side.
F3
10
MB-1
10
Front axle, left side.
A4
25
MB-2
25
Bumper frame, right side.
G4
25
MB-2
25
Bumper frame, left side.
Table 4-6.
Tiedown Data forM35 Truck in C-5A
Aircraft (Fig 4-6)
Tiedown Fitting
Tiedown Device
Capacity
Capacity
Desig-
in
in
nation
1,000 lb
Type
1,000 lb
Attach to Item
E1l
25
MB-2
25
Bumper frame, right side.
F1l
25
MB-2
25
Bumper frame, left side.
E2
25
MB-2
25
Pintle.
F2
25
MB-2
25
Pintle.
E3
25
MB-2
25
Front axle, right side.
F3
25
MB-2
25
Front axle, left side.
E4
25
MB-2
25
Bumper frame, left side.
F4
25
MB-2
25
Bumper frame, right side.
Table 4- 7.
Tiedown Data for Typical Shelter-Mounted Items
Secured to Two Interlocked 463L Pallets
(HUC-6/E) (Fig 4- 7)
Tiedown Fitting
Tiedown Device
Capacity
Capacity
Desig-
in
in
nation
1,000 lb
Type
1,000 lb
Attach to Item
29
7.5
MB-1
10
Tiedown, left bottom.
30
7.5
MB-1
10
Tiedown, right bottom.
23
7.5
MB-1
10
Tiedown, left bottom.
4
7.5
MB-1
10
Tiedown, right bottom.
22
7.5
MB-1
10
Tiedown, aft left top.
5
7.5
MB-1
10
Tiedown, aft right top.
20*
7.5
MB-1
10
Tiedown, forward left top.
7 '
7.5
MB-1
10
Tiedown, forward right top.
14
7.5
MB-1
10
Tiedown, aft left bottom.
13
7.5
MB-1
10
Tiedown, aft right bottom.
*Not required for C-5 aircraft.
c.
Aircraft Commander Responsibilities.
The
aircraft commander, or designated representative, will
ensure that the loaded equipment is secured in
accordance with restraint criteria outlined in TO 1C-XX-
9.
4-4.
Safety
In addition to the safety precautions contained in
chapter 3, the following procedures should be noted:
a.
The activity offering the equipment for air
transport must notify the pilot in command or designated
representative, when ammunition or explosives are to
be transported and ensure that all hazardous materials
have prepared for shipment in accordance with TM 38-
250.
b.
The vehicle fuel tanks must not be more than
three-fourths full.
c.
Vehicles must be tied down in accordance with
procedures prescribed by TO 1C-130-9, TO 1C-141B-9,
or TO 1C-5A-9, as appropriate.
d.
Each vehicle or component must be checked
carefully to ensure that all loose items are properly
secured.
WARNING
Fire extinguishers must be readily
available during all loading and
unloading operations.
WARNING
Proper ventilation must be provided
during
loading
and
unloading
operations if the XM1058 truck
transporter
engine
is
running.
Prolonged
exposure
to
carbon
monoxide fumes may be fatal.
CAUTION
Do not allow the vehicle speed to
exceed 3 miles per hour inside the
aircraft or on the loading ramps.
4-5.
Preparation of Equipment.
a.
Turret
traverse
and
launch-elevating
mechanism must be in the travel position, locked, and
wire-tied to prevent rotation.
b.
Antennae must be tied down or removed;
cupola must be placed in the closed position; and loose
gear must be secured with nylon cord or a suitable
substitute.
c.
Mirrors from the XM1058 truck transporter must
be removed and secured in the carrier.
d.
The infra lens (IR) must be covered.
e.
The fire unit battery must be completely
protected and secured so that leakage of acid cannot
occur
(TM
38-250/NAVSUP
PUB505(REV)/MCO
P4030.19D/DSAM4145.3, 22 March 1976).
f.
TM 38-250 (AFR 71-4) must be consulted to
ensure compatibility of any additional cargo being
considered for loading with the ROLAND missile
system.
g.
All externally and internally stowed equipment
must be secured.
h.
The vehicle transmission must be placed in
neutral, and the brakes must be set.
i.
The vehicle fuel tanks must not be more than
three-fourths full (TM 38-250 (AFR 71-4)).
j.
Ten ROLAND missile rounds are permitted on
board the aircraft (certificate of equivalency (COE) AY-
84-191).
4-6


Back to Top