LO-5-3805-254-12

TRUCK, DUMP, 20-TON, 6 X 4, ON-OFF HIGHWAY, 71,000 GVW

LUBRICATION ORDER

FEBRUARY 1993
LO-5-3805-254-12

  LO-5-3805-254-12 - Page 1 of 8

LUBRICATION ORDER
LO 5-3805-254-12
25 February 1993
(Supersedes LO 5-3805-254-12,
dated 20 January 1988)
TRUCK, DUMP: 20-TON, 6 X 4,
ON-OFF HIGHWAY, 71,000 GVW
IHC MODEL F-5070 (CCE)
Reference: TM 5-3805-254-10, TM 5-3805-254-20, and C9100-IL.
Intervals (on-condition or hard time) and the related
man-hour times are based on normal operation. The
man-hour time specified is the time you need to do all
the services prescribed for a particular interval.
On-condition (OC) oil sample intervals shall be
applied unless changed by the Army Oil Analysis
Program (AOAP) laboratory. Change the hard time
interval if your lubricants are contaminated or if you
are operating the equipment under adverse
operating conditions,
including longer-than-usual
operating hours. The hard time interval may be
extended during periods of low activity. If extended,
adequate preservation precautions must be taken.
Hard time intervals will be applied in the event AOAP
laboratory support is not available.
WARNING
Dry cleaning solvent, P-D-680, is toxic and
flammable. Always wear protective goggles
and gloves, and use only in a well-ventilated
area. Avoid contact with skin, eyes, and
clothes, and DO NOT breathe vapors. DO NOT
use near open flame or excessive heat. The
solvent’s flash point is 100°F-138°F
(38°C-59°C). If you become dizzy while using
cleaning solvent, immediately get fresh air and
medical help.
If solvent contacts eyes,
Immediately wash your eyes and get medical
aid.
Clean fittings before lubricating. Clean parts with dry
cleaning solvent P-D-880, Type II or equivalent. Dry
before lubricating.
Broken arrow shafts (- - -) indicate lubrication
points on both sides of the equipment.
The lowest level of maintenance authorized to
lubricate a point is indicated by one of the following:
(C) for Crew/Operator,
or (0) Organizational
Maintenance.
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this manual. If you find any mistakes or if you know of a way to improve the
procedures, please let us know. Mail your letter or DA Form 2028 (Recommended Changes to
Publications and Blank forms) direct to: Commander, U.S. Army Tank-Automotive Command, ATTN:
AMSTA-MB, Warren, Ml 48397-5000. A reply will be furnished to you.
Approved for public release; distribution is unlimited.
TA701863
LO 5-3805-254-12
CARD 1 OF 8


Back to Top