TB-9-2320-302-13-P-3
CREW PROTECTION KIT; AIR CONDITIONING KIT PART 3 OF 3
TECHNICAL BULLETIN; OPERATOR’S, UNIT, AND DIRECT SUPPORT, MAINTENANCE MANUAL, INSTALLATION INSTRUCTIONS, AND REPAIR PARTS AND SPECIAL TOOLS LIST
MARCH 2008
TB-9-2320-302-13-P-3 - Page 91 of 240
TB 9-2320-302-13&P-3
0015 00-1
A/C SYSTEM MAINTENANCE
0015 00
THIS WORK PACKAGE COVERS
Leak Test, Recovery, Evacuation, Charging
INITIAL SETUP
Maintenance Level
Direct Support
Tools and Special Tools
Tool Kit, General Mechanic’s (Item 9, WP 0024 00)
Reclaimer, Refrigerant (Item 5, WP 0024 00)
Tool Kit, Refrigeration Equipment (Item 10, WP
0024 00)
Materials/Parts
Oil, Lubricating, Refrigerant Compressor (Item 8,
WP 0025 00)
Rag, Wiping (Item 9, WP 0025 00)
Refrigerant (Item 10, WP 0025 00)
Personnel Required
Two
References
WP 0004 00
Equipment Conditions
Vehicle parked on level ground (TM 9-2320-363-
10)
Parking/Emergency Brake applied (TM 9-2320-
363-10)
Engine OFF (TM 9-2320-363-10)
Ignition Key Switch in OFF position (TM 9-2320-
363-10)
WARNING
•
Contact with refrigerant can cause frostbite. Keep hands and face away to prevent personal injury.
•
Protective face shield must always be worn when refrigerant lines are opened, even if the gauges indi-
cate the system is empty.
•
Always use caution if a fitting is removed. Slowly loosen the fitting. If the system is still under any
pressure, release it slowly in a well-ventilated area.
•
DO NOT smoke when servicing A/C or wherever refrigerant gas may be present.
•
Failure to follow these warnings may result in injury or death to personnel.
NOTE
Replace receiver/dryer if one or more of the following conditions occurs before you purge A/C system:
•
A/C system has been previously opened for service.
•
Too much air or moisture in A/C system, indicated by low refrigerant.
•
Receiver/dryer has been operated for 2 or more years.
•
A/C system opened for longer than 5 minutes.
•
Large A/C system leak (break in hose or line).
Back to Top
