TM-9-2320-260-34-2

TRUCK, 5-TON, 6X6, M809 SERIES (DIESEL)

TECHNICAL MANUAL; DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE; VOLUME 2 OF 2

JULY 1994

TM-9-2320-260-34-2 - Page 215 of 863

TM 9-2320-260-34-2

I5-38. CEILING REGISTERS AND DEFLECTORS REPLACEMENT

THIS

TASK COVERS:

a. Removal

b. Installation

INITIAL

SETUP

APPUCABLE MODELS

EQUIPMENT CONDITION

M820, M820A1, M820A2

Parking brake set (TM 9-2320-260-10).

TOOIS

GENERAL SAFETY INSTRUCTIONS

General mechanic’s tool kit

Gloves, eyeshields, and dust mask must be worn

(Appendix B, Item 1)

during register and deflector replacement.

REFERENCES (TM]

TM 9-2320-260-10

TM 9-2320-260-34P-2

WARNING

Van body is insulated with fibrous glass felt insulation. Gloves,

eyeshields, and dust mask must be worn during register and

deflector replacement. Failure to do so may result in injury to

personnel.

NOTE

●

All ceiling registers and cleflectors are replaced the same. This

procedure covers the replacement of one register and deflector,

●

Registers and deflectors in M820, M820A1, and M820A2 vehicles

are replaced the same. This procedure covers the M820 and

M820A2 vehicles.

a. Removal

1. Remove two screws (5) and register (6) from ceiling side panel (4) and deflector (2).

2. Remove twelve screws (1) and deflector (2) from air duct (3) and ceiling side panel (4).

3. Remove two screws (8) and register (7) from air duct (3).

1. Install register (7) on air duct (3) with two screws (8).

2. Install deflector (2) on air duct (3) and ceiling side panel (4) with twelve screws ( 1).

3. Install register (6) on ceiling side panel (4) and deflector (2) with two screws (5).

15-154