TM-9-2320-304-14-P

LOAD HANDLING SYSTEM, HEAVY EXPANDED MOBILITY TACTICAL TRUCKS (HEMTT)

TECHNICAL MANUAL; OPERATOR’S, ORGANIZATIONAL, AND DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)

AUGUST 2000
TM-9-2320-304-14-P

  TM-9-2320-304-14-P - Page 5 of 1320

TM 9-2320-304-14&P
Change 1
c
WARNING
Container lock could drop suddenly if not supported. Failure to comply may result in injury to personnel.
WARNING
CROP weighs 3,800 lbs. (1 724 kg). Six CROPs weigh 22,800 lbs. (10 342 kg). Make sure all personnel
stand clear of CROP when CROP is being moved. Failure to comply may result in severe injury or death to
personnel.
WARNING
Crossmember assembly weighs 530 lbs. (240 kg). Attach lifting device to prevent possible injury to
personnel.
WARNING
Cylinder weighs in excess of 210 lbs. (95 kg). Attach suitable lifting device prior to lifting to prevent
possible injury to personnel.
WARNING
Cylinder weighs in excess of 210 lbs. (95 kg). Attach suitable lifting device prior to installation or removal
to prevent possible injury to personnel.
WARNING
Do not allow front lift adapter to contact the ground when half-height container front hooks are not
engaged with container upper corner castings. Failure to comply may result in damage to equipment and
injury or death to personnel.
WARNING
Do not attempt loading or unloading operations on a side slope greater than 5 degrees and/or fore/aft slope
greater than 20 percent. Before attempting loading or unloading operations on slopes, determine if ground
surface conditions permit safe loading or unloading operations. Slopes that contain snow, ice, loose gravel,
or sand may not permit safe loading or unloading.
WARNING
Do not get under LHS when disconnecting or connecting connectors and hoses. A hydraulic malfunction
could cause LHS to lower causing serious injury or death.
WARNING
DO NOT grind or sand painted equipment without high-efficiency, air-purifying respirators in use.
WARNING
DO NOT let skin or eyes come in contact with CARC paint. Always wear protective equipment (gloves,
ventilation mask, safety goggles, etc.).
WARNING
Do not put hands, arms, or any body parts under container when positioning chock blocks. Failure to
comply may result in injury or death to personnel.
WARNING
Do not reduce tire pressure when loaded with FRS or container. Highway tire pressure, 60 psi (414 kPa)
front and 83 psi (572 kPa) rear, is required at all times when loaded with FRS or container. Failure to
comply could result in damage to equipment and severe injury or death to personnel.


Back to Top