TM-9-2320-366-20-1
M1083 SERIES, 5 TON, 6x6, MEDIUM TACTICAL VEHICLES (MTV)
TECHNICAL MANUAL; MAINTENANCE INSTRUCTIONS; UNIT MAINTENANCE; VOLUME NO. 1 OF 5
FEBRUARY 2006
CHANGE 3
TM-9-2320-366-20-1 - Page 101 of 1824
TM 9-2320-366-20-1
CHAPTER 2
VEHICLE MAINTENANCE
Section I. REPAIR PARTS, TOOLS, SPECIAL TOOLS, TEST, MEASUREMENT, AND DIAGNOSTIC
EQUIPMENT (TMDE), AND SUPPORT EQUIPMENT .
...............................
2
-2
2-1. COMMON TOOLS AND EQUIPMENT.
..............................................
2
-2
2-2. SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT .
................................
2
-2
2-3. REPAIR PARTS .
.............................................................
2
-2
Section II. SERVICE UPON RECEIPT .
..................................................
2
-2
2-4. UNPACKING AND DEPROCESSING .
..............................................
2
-2
2-5. HAND RECEIPT MANUAL AND INVENTORY OF EQUIPMENT .
...........................
2
-2
2-6. SERVICE BEFORE OPERATION .
.................................................
2
-3
Section III. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) .
.....................
2
-6
2-7. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) INTRODUCTION .
...........
2
-6
2-8. GENERAL MAINTENANCE PROCEDURES .
.........................................
2
-6
2-9. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) TABLE.
...................
2
-7
Section IV. TROUBLESHOOTING .
.....................................................
2-59
2-10. INTRODUCTION TO LOGIC TREE TROUBLESHOOTING .
..............................
2-59
2-11. TROUBLESHOOTING INSTRUCTIONS .
...........................................
2-59
2-12. ENGINE SYSTEM TROUBLESHOOTING .
..........................................
2-71
2-13. FUEL SYSTEM TROUBLESHOOTING .
...........................................
2-109
2-14. EXHAUST SYSTEM TROUBLESHOOTING.
........................................
2-127
2-15. COOLING SYSTEM TROUBLESHOOTING .
........................................
2-137
2-16. ELECTRICAL SYSTEM TROUBLESHOOTING .
.....................................
2-155
Volume 2
2-16. ELECTRICAL SYSTEM TROUBLESHOOTING (CONT) .
...............................
2-943
2-17. TRANSMISSION SYSTEM TROUBLESHOOTING .
..................................
2-1581
2-18. PROPELLER SHAFT TROUBLESHOOTING .
......................................
2-1823
2-19. POWER TAKE-OFF (PTO) TROUBLESHOOTING .
..................................
2-1831
2-20. BRAKE SYSTEM TROUBLESHOOTING .
.........................................
2-1835
2-21. AIR SYSTEM TROUBLESHOOTING.
............................................
2-1947
2-22. WHEEL TROUBLESHOOTING .
................................................
2-1989
2-23. HYDRAULIC SYSTEM TROUBLESHOOTING .
.....................................
2-1997
Volume 3
2-24. CENTRAL TIRE INFLATION SYSTEM (CTIS) TROUBLESHOOTING .
....................
2-2007
2-25. AXLE TROUBLESHOOTING .
.................................................
2-2143
2-26. STEERING TROUBLESHOOTING .
.............................................
2-2151
2-27. FIFTH WHEEL TROUBLESHOOTING.
...........................................
2-2173
2-28. SUSPENSION SYSTEM TROUBLESHOOTING.
....................................
2-2189
2-29. 15K SELF-RECOVERY WINCH (SRW) SYSTEM TROUBLESHOOTING.
..................
2-2205
2-30. STEERING HYDRAULIC SYSTEM TROUBLESHOOTING .
............................
2-2213
2-31. AIR TRANSPORT TROUBLESHOOTING .
........................................
2-2219
2-32. DUMP BODY HYDRAULIC SYSTEM TROUBLESHOOTING .
..........................
2-2237
2-33. WRECKER HYDRAULIC SYSTEM TROUBLESHOOTING .
............................
2-2243
2-34. SPECIAL PURPOSE KIT TROUBLESHOOTING .
...................................
2-2271
2-35. M1084/M1086 MATERIAL HANDLING CRANE (MHC) HYDRAULIC TROUBLESHOOTING .
....
2-2409
2-36. CAB TILT AND SPARE TIRE RETAINER TROUBLESHOOTING .
.......................
2-2413
Change 1
2-1
Back to Top
