TM-9-2815-220-34
ENGINE, WITH CONTAINER:TURBOSUPERCHARGED, DIESEL ,FUEL INJECTION ,90-DEGREE “V” TYPE, AIR - COOLED, 12-CYLINDER, ASSEMBLY; MODELS AVDS-1790-2C (2815-00-410-1203) AND AVDS-1790-2D (2815-00-410-1204)
TECHNICAL MANUAL; DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TM-9-2815-220-34 - Page 241 of 532
Fiuw·c
;.95±
RC1±²ovI±²g
o»
³1´stalLInG µT'<¶±²S¸¹²iº»³V¼½ .:a/¾e r¿m1ÀÁÂ-
tor bmckRl,
MOdEL
²\VDS-17³0´2C
U±1D
JµvDS¶/·¸¹º»!D
ÃÄ1¸Å³±²ÆÇÈ
c.
RemovE Eight capscrEws, lockwashErs And fLAt
washE±s (FIG. 3-96) sEcur²ng the oIl paN to thE
craNKCAsE³ REmove n´ne cApscrews, µockwAsH¶rs
a·d ¸at wAshers
(1,
¹Igº 3-97) sEcUrING tHe o²l paN to
ThE crAnkcAsE dAmpEr And o²l ¹I»ter HoUs²Ng (2)¼
½emove 27 o¹ ¾8 sel¹-locKIng nUts aNd flAt \ as HErs
(3¿ on each s²dE oÀ the craNkcAse AssemblyÁ ÂEavE
one nUÃ and WashEr ²nstAllEd on eÄcH sIdE o¹ thE oil
panÅ nEar the centEr o¹ the pAN, to preVeNT thE o²µ
pan ÆÇom ¹ÄllING ANd bEIng damAgedÈ SUpPorT ÉhE
oIl pAn adÊqUatElY beFore removING thE two NUËs
And washersÌ thEn rEmovE the oIl pan
(4).
RemovE
OIl
presSuRE
tRan±miTT²³ ´5µ,
b
U
s
H
ig
ÍNd ÎlbOw
ÏÐÑm ÒÓaNÔÕÖ×ÎØ
¼½¾½
ÙemovE E²ght cApscrEws1 lockwAshErs And
Flat washErs ÚÛÜgÝ 3-Þ6¿ secUrINg ThE o²l pan To thE
CraNKcAsEß àemovE NInE cApscrEws, lockwashers
and ¹lat áashErs
±²³
¹iGâ 3ã97) sEcUrING thE oI» paN to
thE cranKcAse dAmper ANd o²l ¹IltE± hoUs²nG (ä)Á
Remåve æç o¹ æè sel¹-lock²NG NUts and ¹lAt wAshErs
(3é on Each sIdE of THe crANkcasE AssemBlyÝ êEavE
one nUt and washEr iNstallEd oN Each sIde o¹ thE oIl
TM 9-28´5µ¶¶0·34
FÉgÊËÌÍ
:T¿À6Á
Î6Ï1ÐÑÒÓÉÔy Õ¸1Ö ³1¸× tnLLÉ1²Y
OiL
JjØ1Ù²
Âear ÃÄÅÆÇÈNÉnÊwËÌÍ
I
Capscrew, lo±k WashER and
Î
S²Lf-lo³King
ÏuÐ AÑd
´µa¶ wash·R
Nat Wash¸¹
4
OIº Pa»
Ò
¼½A¾¿ÀaÁe Damp¸¹ a¾D ÂIl
Ó
OIl p¹EsÃu¹E t¹ansmITtER
FlÄe¹ HÅUsInG
fÚÛÅÊÜÝ
Ô¿ÀÕÖ
ÞÍMßà³NÅ
Or
i¸¹áâãäåæi¼1ç
×ØL
èéê ë1ì
pANë nEAr thE cEntEr oÀ ìhE panë to PríveNî ïðHE o´l
paN F±om ¹all´Ng aNd bE²ng dAmagEdñ òUpport thE
oIl pAn adEQUAteóy ôe¹ore rEmovINg tõE öwo nUts
aNd wAshErs, tHeN remove thE oIl Pan
¸¹).
ÙEmove
HIgh o´l prEssUrE transm²tter ÷øù À²gú 3û9üØý)þ AUxÿlĀ
Iarā geNErAtor hIgh oIl ĂrEssUăe sáItch Ąæé, ąĆpe
Elbow (3¿, tEE
(4)¶
bUsh²nG ÷5)ë and pIćE Elbow Ú6)
ÆĈom crANkcAsγ REmovE NIppµe ÷ĉ)ú
cº
REmove e²ght sEl¹ĊlockINg nċts ANd ¹lČt
washers ÷fčg³ 3-9è) attach´nĎ crČNkCďse damPEĐ
aNd o²µ ¹Ilđer hoUsĒNg to crANkcAse AsēímblĔĕ Ėook
a sU²tAblE cHaIn or Ho²st INto lIFt²ng eyEsÈ ėAĘE Up
hoUs²ng weIght oN ChaIN or hoIst And sEparAte
hoUsIng ¹rom crAnKcAse assEmbly â
NOtE
Do NoT allow hoęĚsINGto resT on stUěs A¹Ĝer
hoUsInĝ ²s separAtEd ¹rom craNkcAsE aĞd
oIğ traNs¹er tUbesĠ ġXtrEme cAUt²ån mUsĢ
ģĤĥ·Ħħ
3
»¼½¾
Back to Top
