TM-9-2320-209-34-2-1
2½-TON, 6X6, M44A1 AND M44A2 SERIES TRUCKS (MULTIFUEL)
TECHNICAL MANUAL; MAINTENANCE; DIRECT SUPPORT AND GENERAL SUPPORT LEVEL; VOLUME 2 OF 2; PART 1 OF 3
MAY 1981
TM-9-2320-209-34-2-1 - Page 386 of 770
TM 9-2320-209-34-2-1
CHAPTER 9
TRANSMISSION TRANSFER SYSTEM GROUP MAINTENANCE
Section I.
SCOPE
9-1. EQUIPMENT ITEMS COVERED.
This chapter gives equipment maintenance
procedures for the transmission transfer assembly for which there are authorized
corrective maintenance tasks at the direct and general support maintenance levels.
9-2. EQUIPMENT ITEMS NOT COVERED.
All equipment items for which corrective
maintenance is authorized at the direct and general support maintenance levels are
covered in this chapter.
Section II.
TRANSMISSION TRANSFER ASSEMBLY
9-3. AIR ACTUATED TRANSMISSION TRANSFER
REPLACEMENT .
TOOLS : Transfer case fixture, pn 8708898
SUPPLIES : None
PERSONNEL: One
ASSEMBLY REMOVAL AND
EQUIPMENT CONDITION :
Truck parked, engine off, wheels chocked.
a. Preliminary Procedures.
(1) Remove floorboard tunnels. Refer to TM 9-2320-209-20.
(2) Remove front axle propeller shaft, transmission-to-transfer propeller
shaft, and forward–rear axle propeller shaft from transfer case. Refer to
Propeller Shaft and Universal Joint Removal and Replacement, TM 9-2320-209-20.
(3) Remove transfer power takeoff shift control lever link. Refer to
Transfer Controls and Linkage with Power Takeoff Removal and Replacement,
TM 9-2320-209-20.
(4) For trucks M49A1C, M49A2C, M50A1, M50A2 or M50A3, remove delivery
pump propeller shaft and auxiliary governor flexible shaft with adapter. Refer to
Propeller Shaft and Universal Joint Removal and Replacement, TM 9-2320-209-20.
(5) Remove spare tire. Refer to TM 9-2320-209-10.
(6) Remove speedometer flexible shaft and adapter. Refer to
Speedometer Assembly Removal, Rep sir, and Replacement, TM 9-2320-209-20.
(7) Remove handbrake cable from transfer. Refer to Handbrake Cable
Assembly Removal and Replacement, TM 9-2320-209-20.
(8) Drain transfer case. Refer to LO 9-2320-209-12/1.
(9) For truck M764, remove power divider propeller shaft and yoke.
Refer to Propeller Shaft and Universal Joint Removal and Replacement,
TM 9-2320-209-20.
9-1
Back to Top
