TM-9-2320-361-20
2-1/2-TON, 6x6, M44A2 SERIES TRUCKS (MULTIFUEL)
TECHNICAL MANUAL; UNIT MAINTENANCE
OCTOBER 1991
TM-9-2320-361-20 - Page 90 of 1207
TM 9-2320-361-20
Table 2-1. Preventive Maintenance Checks and Services (Contd).
S-Semiannually
A-Annually B-Biennially
Item
Interval
Item to be
No.
Inspected
Procedures
S
A
B
4
•
Clutch
Check clutch pedal (5) for 1.5-2.0 in. (3.8-5.0 cm) free travel. If not
within limits, adjust clutch pedal (para. 3-10).
5
•
Brakes
a.
Check brake pedal (3) to make sure it stops no less than
2.0 in. (5.0 cm) above floor. If brake pedal (3) stops less than 2 in.
(5.0 cm) above floor, check brakeshoe adjustment (para. 8-8).
•
b.
Check brake pedal (3) for 0.2-0.5 in. (.06-1.25 cm) free
travel. If brake pedal adjustment is required (para. 8-14).
6
•
Steering system
a.
Check steering wheel (2) and make sure it does not exceed
more than 1 in. (2.5 cm) free play.
•
b.
Turn steering wheel (2) through full range and check for
binding or excessive steering.
7
•
Engine stop
Stop engine (TM 9-2320-361-10).
control
AFTER ROAD TEST
Perform all after-operation weekly and monthly checks in
TM 9-2320-361-10 PMCS. Then make the following inspections in
the order given, including kit items on vehicles so equipped.
WARNIN G
• Do not smoke, have open flame, or make sparks
when performing battery maintenance. Batteries
may explode causing severe injury to personnel.
• Remove all jewelry such as rings, dog tags,
bracelets, etc. If jewelry or disconnected battery
ground cable contacts battery post, a direct short
can result, causing damage to equipment or
severe injury to personnel.
8
Ž
Batteries
Check and record specific gravity of each cell. Check electrolyte
level. If low, add distilled water. Inspect battery cables for frays,
splits, corrosion, and security. Clean top of batteries and lightly
coat terminals with grease (TM 9-6140-200-14).
9
Ž
Air cleaner
Test air cleaner indicator for proper operation (para. 3-16).
indicator
10
•
Data, caution,
Inspect for completeness, security, and readability. Replace if
and warning
necessary.
plates
2-5
Back to Top
