TM-9-2320-365-20-1
M1078 SERIES, 2 1/2-TON, 4 X 4, LIGHT MEDIUM TACTICAL VEHICLES (LMTV)
TECHNICAL MANUAL; MAINTENANCE INSTRUCTIONS; UNIT MAINTENANCE; VOLUME NO. 1 OF 5
FEBRUARY 2006
CHANGE 3
TM-9-2320-365-20-1 - Page 75 of 1760
TM 9-2320-365-20-1
CHAPTER 2
VEHICLE MAINTENANCE
Section I. REPAIR PARTS, TOOLS, SPECIAL TOOLS, TEST, MEASUREMENT, AND DIAGNOSTIC
EQUIPMENT (TMDE), AND SUPPORT EQUIPMENT .
...............................
2
-2
2-1. COMMON TOOLS AND EQUIPMENT.
..............................................
2
-2
2-2. SPECIAL TOOLS, TMDE, AND SUPPORT EQUIPMENT .
................................
2
-2
2-3. REPAIR PARTS .
.............................................................
2
-2
Section II. SERVICE UPON RECEIPT .
..................................................
2
-3
2-4. UNPACKING AND DEPROCESSING .
..............................................
2
-3
2-5. HAND RECEIPT MANUAL AND INVENTORY OF EQUIPMENT .
...........................
2
-3
2-6. SERVICE BEFORE OPERATION .
.................................................
2
-3
Section III. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) .
....................
2-6.1
2-7. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) INTRODUCTION .
..........
2-6.1
2-8. GENERAL MAINTENANCE PROCEDURES .
........................................
2-6.2
2-9. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS) TABLE.
...................
2
-7
Section IV. TROUBLESHOOTING .
.....................................................
2-53
2-10. INTRODUCTION TO LOGIC TREE TROUBLESHOOTING .
..............................
2-53
2-11. TROUBLESHOOTING INSTRUCTIONS .
...........................................
2-53
2-12. ENGINE SYSTEM TROUBLESHOOTING .
..........................................
2-63
2-13. FUEL SYSTEM TROUBLESHOOTING .
...........................................
2-101
2-14. EXHAUST SYSTEM TROUBLESHOOTING.
........................................
2-119
2-15. COOLING SYSTEM TROUBLESHOOTING .
........................................
2-129
2-16. ELECTRICAL SYSTEM TROUBLESHOOTING .
.....................................
2-147
Volume 2
2-16. ELECTRICAL SYSTEM TROUBLESHOOTING (CONT) .
..............................
2-1087
2-17. TRANSMISSION SYSTEM TROUBLESHOOTING .
..................................
2-1359
2-18. PROPELLER SHAFT TROUBLESHOOTING .
......................................
2-1597
2-19. POWER TAKE OFF (PTO) TROUBLESHOOTING .
..................................
2-1603
2-20. BRAKE SYSTEM TROUBLESHOOTING .
.........................................
2-1607
2-21. AIR SYSTEM TROUBLESHOOTING.
............................................
2-1713
2-22. WHEEL TROUBLESHOOTING .
................................................
2-1753
2-23. HYDRAULIC SYSTEM TROUBLESHOOTING .
.....................................
2-1761
2-24. CENTRAL TIRE INFLATION SYSTEM (CTIS) TROUBLESHOOTING .
....................
2-1767
2-25. AXLE TROUBLESHOOTING .
.................................................
2-1895
2-26. STEERING TROUBLESHOOTING .
.............................................
2-1903
2-27. SUSPENSION SYSTEM TROUBLESHOOTING.
....................................
2-1925
2-28. 11K SELF-RECOVERY WINCH (SRW) SYSTEM TROUBLESHOOTING.
..................
2-1945
2-29. STEERING HYDRAULIC SYSTEM TROUBLESHOOTING .
............................
2-1953
2-30. AIR TRANSPORT TROUBLESHOOTING .
........................................
2-1959
2-31. SPECIAL PURPOSE KIT TROUBLESHOOTING .
...................................
2-1977
2-32. CAB TILT AND SPARE TIRE RETAINER ASSEMBLY TROUBLESHOOTING .
..............
2-2115
2-33. FRAME TROUBLESHOOTING .
................................................
2-2121
Section V. MAINTENANCE PROCEDURES .
............................................
2-2127
2-34. MAINTENANCE INTRODUCTION.
..............................................
2-2127
2-35. GROUND HANDLING .
......................................................
2-2127
2-36. GENERAL REMOVAL INSTRUCTIONS.
..........................................
2-2127
2-37. GENERAL DISASSEMBLY INSTRUCTIONS .
......................................
2-2128
2-38. GENERAL CLEANING INSTRUCTIONS .
.........................................
2-2129
Change 1
2-1
Back to Top
