TM-9-2320-366-20-1
M1083 SERIES, 5 TON, 6x6, MEDIUM TACTICAL VEHICLES (MTV)
TECHNICAL MANUAL; MAINTENANCE INSTRUCTIONS; UNIT MAINTENANCE; VOLUME NO. 1 OF 5
FEBRUARY 2006
CHANGE 3
TM-9-2320-366-20-1 - Page 112 of 1824
TM 9-2320-366-20-1
Table 2-1. Preventive Maintenance Checks and Services (Cont)
Item
No.
Interval
Location
Item to be
Checked or
Serviced
Procedure
Not Fully
Mission
Capable If:
1
Semiannual
Preservice
Checks
(CONT)
NOTE
Do not turn tires when turning wheel to
check for steering wheel free play.
f.
Place a strip of tape around steering wheel
at 12 O’clock position. Turn steering wheel
right until resistance is felt. Place a ruler
lightly against outer rim of steering wheel
with end of ruler at one edge of tape. Turn
steering wheel left until resistance is felt.
Measure distance designated edge of tape
has traveled. Maximum free play measured
at outside rim of steering wheel is 2-1/2 in.
(6.4 cm).
f.
Steering wheel
exceeds 2-1/2 in.
(6.4 cm) free
play.
g.
Apply brake pedal with steady force. Vehicle
should slow down and stop without pulling
to one side or jerking. Release brake pedal.
The brakes should release immediately and
without difficulty.
g.
Brakes
chatter, pull to
one side, will not
release, or do
not work.
h.
Observe vehicle response to road shocks,
side sway or continuous bouncing indicates
a malfunction.
h.
Handling is
unstable.
CAUTION
Do not hold steering wheel at full left or
right position for longer than 10 seconds.
Oil overheating and pump damage can
result. Failure to comply may result in
damage to equipment.
i.
With vehicle stopped, turn steering wheel to
extreme left, then to extreme right to check
for binding or jerking.
i.
Hard steering
is evident.
j.
Check engine operation at all speeds. Ensure
that engine does not go over engine
governed speed - (55 mph or 2600 rpm).
j.
Engine
exceeds or fails
to reach
governed speed.
2-10
Back to Top
