TM-9-2815-220-34
ENGINE, WITH CONTAINER:TURBOSUPERCHARGED, DIESEL ,FUEL INJECTION ,90-DEGREE “V” TYPE, AIR - COOLED, 12-CYLINDER, ASSEMBLY; MODELS AVDS-1790-2C (2815-00-410-1203) AND AVDS-1790-2D (2815-00-410-1204)
TECHNICAL MANUAL; DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE MANUAL
TM-9-2815-220-34 - Page 92 of 532
TM 9-2815±²³0´34
2-19. GeneratoR
a.
model AVDSµL 7¶·¸¹C
ENgi±²
(I) ³´mOvAlµ
¶·¸
Remo,•e self-lOcking nut aNd ±aT washer
(I ²
F³g.
2´14) and disCONneµT assemblEd w³¶iNg
ha·ess cabLe
¹º»¼
¸nstaLL seLF-¹OcK³ng nUT and ºaT
wAsHe¶» ¼emOve s½Lf¾LOµ¿inG nÀT aÁd ÂaT washe¶
Ã3)
½¾d
DisµOÄneµT
assemBLed
eleµTÅicaÆ
Lead
Ãg¶OÀndÇ
4¿À
¸ÈsTaLL seLf-ÉOµÊËng nÀt And ºaT washeÅÌ
Á bÂ
¼emOVÍ µapscrew and twO Îat wasÏeÅs
(5) and ¶ÐMOVe and rÍTa³n asseÑbLed eLeµtr³cal lÍad
(ÒrOÀNdÇ
4Ã
FÓr
insTaLlaT³On
On
¶epÆaµemenT
geneÔaTO¶Õ
Öis×OnneµT
wiųng
ØAÙess
ÄLÄcTÅÆCÇÈ
Leads
É6Ê ÇËd Ì7ÍÎ
I Sci
f-locLing Nut and ±A 1 wAsher
2
²S³EmbleD E´ECUical caBlE
3
µe¶F-JO·kinG Nu1 anD ¸a1 Wa¹hER
4
ºs»emBlED E¼½¾T¿iÀÁl leAD (ÂÃOÄND)
5
ÅapÆcÃEw ÇnD ÈaÉ waÊHEÃ
6
˼eÌtÃi·aÍ ¼eAÎ ÏcOnNeÐÉoÃ)
7
ѼÒÌ1ÃIcÓl ¼EaD ÏcÔnNEcÉoÃÕ
Figure 2-14. ConnEc±I²G oR d³s´onNEctµnG GE¶·aTo¸ ElEcTrIcAL
L¹ads, mOEL ºVDS»¼ 790½¾C ¹¿ÀGInEÁ
ÏÐÑ
DisconneCt oil Inlet hose
ÒÓ,
fig. 2-15) and
drain oil inTo a suItable ContainEr. LoosEn
L
oc
ʳ
n
g
nUt
(2) and removE oi± InlEt Elbow
Ò3ÔÕ
ReMove and disCard
prEformEd pa²king³ ´Etain ElboW, nµT, and ¶asHEr
For insTa±laTion In rep±aCEMEnT gEnErator· ¸Is²onne²T
oi± reT¹rn ºoSe
Ö×ØÙ
´eMove and rEtain
Ú³l
return ºoSe
µnion (»¼½ Remove¾ and dis²ard preforMed paCKing¿
ÚDÛ
DisconnECt genErator rear oiÀ draIn Tube
ÜÝÞ
and front
ÛiL
drain tUbe
ßàá
and drain oil Into a
suItabÁE Âontainer. Remove and retain oIl drain Tee
â8ã
ÃOr instal±ation In rEpÄaÅEMEnt genEratorÆ Çis²onÈ
neCT and rEMove generaTor Ãront oil drain tUBe and/or
ÉeMoVe and retaIn FrOnT oiÊ drain T¹Be eËboÌ and nipÈ
ple Í9¼. ÇisConne²t vent Îose
ÒÓ0äå
´eMove and retain
vEnt Îose adapÏEr (11¼ and vEnT rEstri²tor
ÒÓæÔç
º»¼6
ÜÏanÝÞ
3
èéê
ReMovE nut
ëÓ3ìí
and disengagE generator
²radlE assembÄy reTaining straps Ð14)Ñ Loosen nuÒ (1Ó)
and
rEMoÔe
½¾v"
Band ÅÁamp
îÓïìð
REMoVE GEnerator
(ß7) FàOm µ¶adLÍ assÍmBLy (á8)â ¼ÍmOVe TÆãÍÍ
µaPscäåws
and
ælaT
wasçèäsé
( ê9) aNd
reMOëe
gÍNe¶atOä suPPOrt (20) aNd µradlÍ ìs aN asseÑBLyí
±
Öi× in¼eØ hOse
²
ÙÔcKiÚÛ nÜt
³
ÝÞ¼ ßnleà eláâw
´
ãi× ÃetÜÃä hâse
s
ãi¼ åEàÜæN hoÊç ÜNèén
µ
êëAr Oì¼ DÃAèn tÜíE
¶
îÃoït oil Dðain tñbe
8
Öò¼ DÃaiN tee
9
Öól DÃain ôõáE Elbow anD ö÷pp¼e
10
Vønt hoÊe
·1
VEnà hose aùapàEÃ
1¸
VEnô reÊtricàOr
¹º
úÜt
1»
ûTÃüP
·¼
ýut
·6
"Vþ ÿanD claMp
½7
ĀeāĂÃatoÃ
·8
㥹¼E 3sĆEćÿ¼y
19
ĈĉpĊċÃeČ aND ¸ač WAÊHeÃ
¾¿
ĎÜppoÃt
²1
ĎcÃew
fÂGu¸E 2ÃÄ5Å ÆEMÇvInG or µÈTÉllInG ÊEËÌÍratorÎ ÏÐdEl
ÑÒDÓÔÕÖ90»2C ×ØÙIËÚeÛ
I
ñò
îOsiTiOn gene¶atOr cOUïliNg tðOl² ñaÔt
òOó 1168ô15õö On geNeratOr d÷³øe adaïTeÅ (2) and
seµUre witØ band µLamï (ù)ú ûsing sUiTaBLÍ BLOcÊü
ing maTe¶iaLé bLOcÊ the c¶aNÊsÏafý sO it w³lL NOt
rOTaTÍþ ÿsiNg
a
ù00 pOĀNdāfÍet µapacity tOäquÍ
wreNcÏĂ remOëÍ baµălash aNd g¶adÀalĄy ³Nc¶eaSÍ
TO¶QUe TO ê67 ïOÀndąfeÍT (ĆćgĈ 2ĉê5Ċ1 )ú If SLipïage
OcµU¶s beLOw 16ċ ïOÀndČFeet² TØe d¶³Ve gearshaæT is
defeµTiøÍ
and mÀsT be ¶epLacÍdč ĎheďÊ TO¶ĐÀeđ
rOtaTiOnal ĒLeÎecTiON ¶ateó ēsing same µOUpl³ng TOOL
and TOrqUe w¶enchĔ aĕpLy ê67 ïOÀndĖėĘeT tOrqUeę
òOte defl͵T³ON iN degrees FrOm zerO TO¶qÀå TO 167
pOÀNd-FÍet
tO¶qÀeó
¸F
rOTat³ON
³s
less
tÏan
8
deg¶eesĚ
O¶
greaTͶ thaN
êě degreesĜ The
d¶iVe
geaĝsÏaft is defeµT³ëe
and
ÑÀsT be ¶eïLaµedþ
Back to Top
