TM 9-2320-362-14&P
HEADQUARTERS
TECNICAL MANUAL
NO. 9-2320-362-14&P
DEPARTMENT OF THE ARMY
Washington D.C.,
28 April 1992
TECHNICAL MANUAL
OPERATOR, UNIT, DIRECT SUPPORT AND GENERAL SUPPORT
MAINTENANCE MANUAL INCLUDING
REPAIR PARTS AND SPECIAL TOOLS LIST FOR
ELECTRICAL ENVIRONMENTAL SYSTEM (EES) KIT USED ON
TRUCK, UTILITY:
S250 SHELTER
CARRIER,
4X4, M1037
FOR TRAFFIC JAM AN/TLQ-17A(V)3 (HMMWV)
REPORTING ERRORS AND RECOMMENDING IMPROVENENTS
You can help improve this manual .
If you find any mistakes, or
if you know of a way to improve the procedures, please let us
know.
Mail your letter or DA Form
2028 (Recommended Changes
to
Publications and Blank Forms),
or DA Form 2028-2 located in the
back of this manual direct to:
Commander, U.S. Army Tank-Automotive
Command, ATTN: AMSTA-MB, Warren, MI 48090-5000. A reply will be
furnished to you.
CHAPTER 1.
Section I.
II.
CHAPTER 2.
Section I.
II.
III .
IV.
CHAPTER 3.
Section I.
II.
III.
IV.
V.
VI.
VII .
CHAPTER 4.
Section I.
HOW TO USE THIS MANUAL . . . . . . . . . . . . . . . . . . . . . . . .
INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . .
Equipment Description . . . . . . . . . . . . . . . . . . . . . . . . .
OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . .
Description and Use of Operator’s Controls
and Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operator Preventive Maintenance Checks
and Services (PMCS) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation Under Usual Conditions . . . . . . . . . . . . . .
Operation Under Unusual Conditions . . . . . . . . . . . .
UNIT MAINTENANCE . . .’ . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lubrication Instructions . . . . . . . . . . . . . . . . . . . . . .
Repair Parts; Special Tools; Test,
Measurement, and Diagnostic Equipment (TMDE);
and Support Equipment
. . . . . . . . . . . . . . . . . . . . . . . . .
Service Upon Receipt . . . . . . . . . . . . . . . . . . . . . . . . . .
Unit Preventive Maintenance Checks
and Services (PMCS) . . . . . . . . . . . . . . . . . . . . . . . . . . .
Unit Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . .
Truck Cab Components Maintenance . . . . . . . . . . . . . .
Electrical Components Maintenance . . . . . . . . . . . . .
DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE .
Repair Parts; Special Tools; Test, Measure-
ment, and Diagnostic Equipment (TMDE); and
Support Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Page
1-1
1-1
1-3
2-1
2-1
2-4
2-7
2-7
3-1
3-1
3-1
3-1
3-2
3-6
3-27
3-47
4-1
4-1
i
Approved for public release; distribution is unlimited.