TM-9-1290-365-24-P

PALADIN MUZZLE VELOCITY SYSTEM M93 UPGRADED

TECHNICAL MANUAL; UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST

OCTOBER 2000

  TM-9-1290-365-24-P - Page 179 of 334

ARMY TM 9-1290-365-24&P
Table D-2. Test Equipment and Special Tools Required (Cont)
Nomenclature
Part/Spec. No.
Figure
SMA Female/SMA Female Adapter
Midwest Microwave, 2595
C-11, 31
N-Type Female/SMA Male Adapter
Midwest Microwave, 2682
C-11, 32
ESD Work Station Kit
M87893-02
C-11, 13
D.4.3 Materials Required.
Repair materials and other consumable items required are listed in Table
Table D-3. Materials Required
Nomenclature
Part/Spec. No.
Appendix F
Item No.
Paint
Color No.383 lAW FED-STD-595 CARC
21
Adhesive
MIL-A-46146, Type III
19
Insulation Compound
MIL-l-46058 TYPE 1B31
9
Solder
SN63WRMAP3
23
Lacing Tape
MIL-T-43435-B3/BLK
11
Solder Sleeve
M8351 9/1-2
28
Bus Wire
QQ-W-343/S-22-S1 T
13
Sealing Compound
83-31
16
Primer
747-55
17
Adhesive
S1125
2
Adhesive
RTV732
29
Acetone
0A51
1
Lockwire
M520995-C22
30
Methylethylketone
ASTM-D-740
14
Antistatic Bag
3271576
31
D.4.4 General Repair Requirements.
The following general requirements apply to repair of the
transceiver assembly:
a. GENERAL. The transceiver does not contain high voltages or hazardous material. The
transceiver radiates low-power X-band microwave energy, therefore RE safety precautions
should be taken.
b. RF-SAFETY. The transceiver radiates microwave energy at approximately 1 mW/cm
2
power
density at the antenna surface. Maximum safe level is 10 mW/cm
2
lAW safety level of
electromagnetic radiation with respect to personnel. The radar output field does not exceed the
safety levels required by ANSI C95.1 - 1982, hazard for humans, by electromagnetic fields at
normal or malfunction operation conditions. The transceiver output power is less than 220 mW,
which is at any time three orders of magnitude below the requirements of MIL-STD-1358B.
Although transmitted power density is less than the safety level, comply with the following
warning when the transceiver is transmitting:
Change 1
D-9


Back to Top