TM-9-2320-361-10
2-1/2-TON, 6x6, M44A2 SERIES TRUCKS (MULTIFUEL)
OPERATOR'S MANUAL
DECEMBER 1988
TM-9-2320-361-10 - Page 284 of 392
TM 9-2320-361-10
3-8. GENERAL (Contd)
• Front winch
• Rear winch
• Cooling system
• Special body equipment
•
Special purpose kits
Below these major headings are the symptoms and the corrective action.
NOTE
Operators should perform the corrective action in the order
listed until the malfunction is corrected. If none of the steps
correct the malfunction, notify your supervisor.
b. Omissions.
This manual cannot list all malfunctions that may occur. If a
malfunction occurs that is not listed in table 3-1, notifty your supervisor.
c. Symptom Index.
To find a specific malfunction, refer to the symptom index
below:
3-9. TROUBLESHOOTING SYMPTOM INDEX
MALFUNCTION
MALFUNCTION
PAGE
NO.
NO.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
ENGINE
Engine starter button is pressed but engine
fails to start . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Engine cranks but does not start . . . . . . . . . . . . . . . . . 3-6
Engine cranks but fails to start at outside
temperatures below 0°F(-17°C) . . . . . . . . . . . . . . . . . 3-6
Engine starts but misfires, runs rough,
or lacks power . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . 3-7
Engine overheats as indicated by engine coolant
temperature gage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Low engine oil pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Excessive exhaust smoke after engine reaches
normal operating temperature 180°F to 200°F . . . . 3-8
TRANSMISSION
No response to gear shift lever movement . . . . . . . . . 3-8
Rough shifting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Lubricant leakage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
TRANSFER CASE
Transfer case shift lever will not shift or slips
out of gear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
Transfer case lubricant leakage . . . . . . . . . . . . . . . . . . . 3-8
3-3
Back to Top
