TM-9-2320-387-10

TRUCK, UTILITY: S250 SHELTER CARRIER, 4X4, M1113

OPERATOR’S MANUAL

OCTOBER 2001

CHANGE 1

TM-9-2320-387-10 - Page 195 of 277

TM 9-2320-387-10

3-12

3-12. SERVICING BATTERIES

a.

Unhook latches (6) and remove companion seat (1) from battery box (9).

WARNING

Do not perform battery system checks or inspections while smoking or

near fire, flames, or sparks, especially if the caps are off. Batteries

may explode, causing damage to vehicle and injury or death to

personnel.

b.

Check electrolyte level.

(1)

Remove all battery filler caps (2) and check electrolyte level. If electrolyte

level is below ledge in battery filler opening, add distilled water (appendix D, item 7).

(2)

A battery that is continually in need of electrolyte may indicate an

improperly adjusted charging system. Notify unit maintenance if problem continues.

(3)

Inspect vented battery filler caps (2) to ensure that vents are clear,

unobstructed, and permit escape of battery gases. Clean vents if obstructed; replace

caps (2) if damaged.

(4)

Install filler caps (2).

c.

Inspect all battery compartment components, including terminal clamps (5),

battery cables (3), battery holddowns (8), and shunt (4) for corrosion, damage, or

looseness. Inspect terminal boots (7), if installed. Notify unit maintenance if any of

these problems exist.

d.

Ensure that battery terminal clamps (5) have a light coat of lubricating oil for

corrosion protection (appendix D, item 23).

e.

Install companion seat (1) and secure to battery box (9) with latches (6).

f.

Refer to TM 9-6140-200-14 for additional information.