TM-9-2815-237-34
ENGINE, DIESEL: 8 CYLINDER, 6.2 AND 6.5, NORMALLY-ASPIRATED, DETUNED AND TURBOCHARGED
TECHNICAL MANUAL; DIRECT SUPPORT AND GENERAL SUPPORT MAINTENANCE
JULY 2004
CHANGE 2
TM-9-2815-237-34 - Page 24 of 267
TM 9-2815-237-34
2-8
Change 1
2 - 1 4 .
MOUNTING ENGINE ON REPAIR STA N D
This task covers:
a.
Installation
b.
Removal
General Safety Instructions
Direct personnel to stand clear during hoisting
operation.
a. Installation
NOTE
Do not perform step 1 if engine lifting sling has been previously
installed.
1.
Position engine lifting sling on engine (4) and secure to right cylinder head (10) with two bolts (11).
Finger tighten bolts (11).
2.
Install sling bracket (2) to engine lifting sling with pin (3) and on left cylinder head (1) with two
bolts (9). Tighten bolts (9) and (11).
WARNING
Direct personnel to stand clear during hoisting operation. Failure
to do this may cause injury to personnel.
3.
Attach hoist to engine lifting sling and hoist engine (4) into position over engine repair stand.
4.
Loosen four capscrews (5) securing repair stand arms (6) on engine repair stand and align arms (6)
with holes in rear of engine (4).
5.
Install repair stand arms (6) to engine (4) with four washers (8) and capscrews (7).
6.
Tighten capscrews (5) and (7).
7.
Disconnect hoist and remove two bolts (11) and (9), engine lifting sling, and bracket (2) from
engine (4).
b. Removal
1.
Position engine lifting sling on engine (4) and secure to right cylinder head (10) with two bolts (11).
Finger tighten bolts (11).
2.
Install sling bracket (2) to engine lifting sling with pin (3) and on left cylinder head (1) with two
bolts (9). Tighten bolts (9) and (11).
3.
Attach hoist to engine lifting sling and hoist engine (4) to relieve pressure on engine repair stand.
4.
Remove four capscrews (7) and washers (8) from repair stand arms (6) and hoist engine away from
engine repair stand.
INITIAL SETUP:
Tools
General mechanic’s tool kit:
automotive (Appendix E, Item 1)
Special Tools
Engine repair stand (Appendix E, Item 2)
Engine lifting sling (Appendix E, Item 3)
Back to Top
