MWO-5-2350-262-35-4
ARMORED COMBAT EARTHMOVER (ACE), M9
MODIFICATION WORK ORDER
MWO-5-2350-262-35-4 - Page 2 of 207
MWO 5--2350--262--35--4
i
MODIFICATION WORK ORDER
HEADQUARTERS
No. 5--2350--262--35--4
DEPARTMENT OF THE ARMY
Modification Work Order
Modification Of Armored Combat Earthmover
(Ace), M9
(NSN 2350--00--808--7100) (EIC ASA)
System Improvement Plan (SIP)
Phase 4 Block Modification
TABLE OF CONTENTS
Page
CHAPTER 1
INTRODUCTION
1--1
..............................................
MWO KITS/PARTS AND THEIR DISPOSITION
1--3
.............................
SPECIAL TOOLS; TOOL KITS; JIGS; TEST, MEASUREMENT,
AND DIAGNOSTIC EQUIPMENT (TMDE); AND FIXTURES REQUIRED
1--10
......
CHAPTER 2
MODIFICATION OF DRIVER’S COMPARTMENT
2--1
.................
SECTION I
PREPARATION FOR MODIFICATION
2--2
.....................................
SECTION II
INSTALLATION OF HDC CONTROL BOX STOWAGE FIXTURE
2--3
..............
SECTION III
INSTALLATION OF HDC CIRCUIT BREAKER
2--7
..............................
SECTION IV
INSTALLATION OF UMBILICAL CABLE DISCONNECT BRACKET
2--8
............
CHAPTER 3
MODIFICATIONS IN BOWL AREA
3--1
..............................
SECTION I
PREPARATION FOR MODIFICATION
3--2
.....................................
SECTION II
INSTALLATION OF HDC PRIMARY MANIFOLD ASSEMBLY, MANUAL
SHUT–OFF VALVE V23, AND LEFT MAIN MANIFOLD PRESSURE
TRANSDUCER T7
3--3
......................................................
SECTION III
MODIFICATION OF MAIN HYDRAULIC FILTER AREA
3--53
.....................
SECTION IV
INSTALLATION OF PRESSURE TRANSDUCER T12
3--67
.......................
SECTION V
MODIFICATION OF ACCESS COVER
3--68
....................................
SECTION VI
INSTALLATION OF BUMP STOP CYLINDERS PRESSURE
TRANSDUCERS T8 AND T9
3--70
............................................
SECTION VII
INSTALLATION OF FORWARD ACTUATORS PRESSURE
TRANSDUCERS T5 AND T6
3--72
............................................
CHAPTER 4
MODIFICATIONS TO UNDERSIDE OF VEHICLE
4--1
.................
SECTION I
PREPARATION FOR MODIFICATION
4--2
.....................................
SECTION II
INSTALLATION OF NEW FORWARD LEFT MANIFOLD ASSEMBLY
4--4
..........
SECTION III
INSTALLATION OF NEW FORWARD RIGHT MANIFOLD ASSEMBLY
4--14
........
SECTION IV
INSTALLATION OF AFT MANIFOLD ASSEMBLY
4--23
..........................
WASHINGTON D.C., 14
DECEM
BER 2008
Back to Top
