TM-5-3805-254-20-2
TRUCK, DUMP, 20 TON, 6X4, ON-OFF HIGHWAY 71,000 GVW, IHC MODEL F-5070 (CCE)
TECHNICAL MANUAL; ORGANIZATIONAL MAINTENANCE MANUAL VOLUME 2 OF 2
JANUARY 1988
TM-5-3805-254-20-2 - Page 6 of 971
TM 5-3805-254-20-2
WARNING
Care must be taken when taking off canister to prevent spilling alcohol.
Injury to personnel could occur.
WARNING
Electrical parts solvent cleaning compound is flammable, and reacts violently with certain metals.
Boiling
point is 114
°
F (46
°
C).
Do not wear jewelry.
Wear safety goggles, rubber gloves, and use only in well
ventilated area.
Avoid contact with skin, eyes, and clothes and don’t breathe vapors.
Do not use near
open flame or excessive heat.
If you become dizzy while using cleaning compound, get fresh air
immediately and get medical aid.
If contact with eyes is made, wash your eyes with water and get medical
aid immediately.
WARNING
Improper cleaning methods and use of unauthorized cleaning liquids or solvents can injure personnel and
cause damage to equipment.
Refer to TM 9-247.
WARNING
Parts of brake assembly will be coated with asbestos dust.
Breathing this dust may be hazardous to your
health.
Use filter mask approved for use against asbestos dust.
Never use compressed air or dry brush
to clean these assemblies.
Dust shall be removed using industrial type vacuum cleaner equipped with
high efficiency filter system.
Clean dirt or mud from brake assemblies with bristle brush or cloth, and
water.
WARNING
Due to excessive weight, assistance will be needed to prevent personal injury when lifting heavy parts.
WARNING
Due to excessive weight, assistance will be needed to lift and remove pintle hook assembly from rear
chassis cross-member.
Serious injury to personnel could result.
WARNING
Safety goggles must be worn when working under truck to prevent eye injury.
WARNING
Hot engine oil could burn you.
Care must be taken to prevent personal injury.
WARNING
Safety goggles must be worn when working with air lines to prevent personal injury.
WARNING
Safety goggles must be worn, when using chisel or drill, to prevent eye injury caused by flying steel chips.
c
Back to Top
