TM-5-3805-254-20-2
TRUCK, DUMP, 20 TON, 6X4, ON-OFF HIGHWAY 71,000 GVW, IHC MODEL F-5070 (CCE)
TECHNICAL MANUAL; ORGANIZATIONAL MAINTENANCE MANUAL VOLUME 2 OF 2
JANUARY 1988
TM-5-3805-254-20-2 - Page 8 of 971
TM 5-3805-254-20-2
WARNING
Assistant must support muffler to prevent falling and causing personal injury.
WARNING
Assistance will be needed to support hood panel to prevent falling and causing personal injury.
WARNING
Assistance will be needed to support air dryer to prevent injury to personnel.
WARNING
Assistant must support fuel tank support to prevent falling and causing injury.
WARNING
When jacking vehicle, be sure vehicle is on level ground.
Put blocks in front and behind each wheel to
prevent vehicle from moving, and support vehicle with trestle stands to prevent personnel injury.
WARNING
Do not operate engine after removing air cleaner housing.
Foreign matter could enter turbocharger air
inlet pipe causing injury to personnel and damage to turbocharger.
WARNING
Due to excessive weight, care must be taken to prevent front hub and brakedrum assembly from falling.
Do not pull out too far on spindle.
Serious injury to personnel could result.
WARNING
Due to excessive weight, assistance will be needed to lift hub and brakedrum assembly.
Failure to
observe this precaution could cause serious injury to personnel.
WARNING
Remove all jewelry, prior to performing any electrical troubleshooting, to prevent accidental short circuits
and/or electric shock.
WARNING
Starter motor solenoid battery terminal is capable of delivering high voltage.
Do not touch or let tools or
metal parts touch starter motor solenoid battery terminal or ground.
Severe personal injury or death could
occur.
WARNING
Do not smoke, use open flame, or allow sparks near batteries.
Mixture of oxygen and hydrogen gases
released from batteries is highly flammable and can explode causing injury to personnel.
e
Back to Top
