TM-1-1500-344-23-4
CONSUMABLE MATERIALS AND EQUIPMENT FOR AIRCRAFT AND AVIONICS VOLUME IV
TECHNICAL MANUAL; CLEANING AND CORROSION CONTROL
SEPTEMBER 2013
TM-1-1500-344-23-4 - Page 15 of 92
2-7
NAVAIR 01-1A-509-4
TM 1-1500-344-23-4
01 September 2013
Table 2-3. Cleaning Compounds (Cont.)
Nomenclature
Specifcation/
Part No.
National Stock
Number
Unit of
Issue
Intended Use
Usable
On
AC AV
Cleaner,
Non-Aqueous,
Low Voc,
Hap-Free
MIL-PRF-32295
Type I
Type II
GL
CO (5 GL)
DR (55 GL)
GL
CO (5 GL)
DR (55 GL)
Non-aqueous environmentally friendly
(less than 25 g/l VOC) cleaner that may
be used as a substitute for MIL-PRF-680.
Type I is for light to medium soils.
Type II is for medium to heavy soils.
X
X
Cleaning
Compound:
Parts Washers
and Spray
Cabinets
MIL-PRF-29602
Type I (Liquid
concentrate)
Type II (Powder
concentrate)
GL
CN (5 GL)
DR (55 GL)
CO (100 LB)
DR (400 LB)
Detergent for use in parts washers and
spray cabinets to clean aviation weapons
systems, engine, and support equipment
components. Removes grease, oil,
and dirt present on disassembled
components.
X
Deicing/Anti-Icing
Fluid, Aircraft
AMS 1424 (supersedes
MIL-A-8243)
Type I (Propylene Glycol
based)
GL
CN (5 GL)
DR (55 GL)
Fluid is generally used heated, either
diluted with water or as supplied, for the
removal of, and for time-limited protection
against, deposits of frost, ice, and snow
on exterior aircraft surfaces prior to take-
off.
X
Cleaning
Compound,
Optical Lens
(Ready to Use)
A-A-59199 (supersedes
MIL-C-43454)
Type I (20% alcohol)
Type II (57% alcohol)
BT (2 OZ)
QT
QT
Cleaning exposed optical surfaces.
X
Disinfectant,
General Purpose,
Phenolic Type,
Concentrate
O-D-1435
Liquid
Powder
BX (4 EA)
BX (12 EA)
Treatment of relief tube areas.
X
Detergent,
General Purpose,
(Liquid,
Non-Ionic)
MIL-D-16791
Type I (Water soluble)
Type II (Oil soluble)
GL
CN (5 GL)
DR (55 GL)
GL
CN (5 GL)
Type I when dissolved in either fresh
water or sea water will remove grease,
oil, and dirt from a wide variety of
surfaces.
Type II when dissolved in kerosene,
diesel fuel, high Fash coal tar naphtha
and similar hydrocarbon solvents will
remove grease, oil sludge, some types of
corrosion preventative compounds and
other similar soils.
Both types are rinseable with either fresh
or sea water.
X
X
Mildew Remover
NAVCLEAN
EA
CO (5 EA)
±or cleaning mildew/mold/fungus from
painted aircraft surfaces and organic
components (rubber, fabric). Supplied
as a four-component kit in a six gallon
reusable container. Each kit makes ²ve
gallons. Solution must be used within 24
hours of mixing.
X
Water Repellent:
Window and
Windshield,
Glass and Plastic
SAE AS6882
(supersedes
MIL-W-6882)
BT (8 OZ)
Anti-wetting ²lm applied to exterior of
glass or acrylic plastic windows and
windshields to assure good visibility
under rain conditions.
X
Back to Top
