TM-10-5411-205-13
SHELTER, ELECTRICAL EQUIPMENT - 250/G
TECHNICAL MANUAL; OPERATOR’S, UNIT, AND DIRECT SUPPORT MAINTENANCE MANUAL
MAY 1995
CHANGE 2
TM-10-5411-205-13 - Page 28 of 127
TM 10-5411-205-13
Section V. MAINTENANCE
Subject
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Repair Procedures . . . . . . . . . . . . . . . . . .
Shelter Assembly
Overall Shelter Assembly
Trough . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bail Handle . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Recessed Step Pan Assembly . . . . . . . . . . . . . . . . .
Drain Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outer Door Assembly
Door Gaskets.
.........
,.. . . . . . . . . . . . . . . .
Door Handle Assembly and Latching Mechanism . . . .
Keeper Assembly . . . . . . . . . . . . . . . . . . . . . . . . .
Hinge Assembly . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Hasp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inner Door Assembly . . . . . . . . . . . . . . . . . . . . . . .
INSTRUCTIONS
. . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . .
. . .
. . . . . . . . .
. . . . . . . . . . . . . .
. . . . . . . . . . . . . .
Louver Assembly, Holder Assembly, and RFI/EMI Filter . . . . . . . . . . . .
Directional Vane Assembly and Air Intake Filter . . . . . . . . . . . . . . . . . .
Louver Cover Assembly Latches . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shield (Rain Flap) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Louver Cover Assembly, .
.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Data Plates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Louver Cover Assembly Strikes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Louver Cover Assembly Clips .
... . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Stay Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Skid Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing Bracket Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lifting Bracket Assembly .
.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sling Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Para
3-8
3-9
3-10
3-11
3-12
3-13
3-14
3-15
3-16
3-17
3-18
3-19
3-20
3-21
3-22
3-23
3-24
3-25
3-26
3-27
3-28
3-29
3-30
3-31
3-32
3-33
3-34
3-35
3-36
Page
3-11
3-12
3-21
3-23
3-25
3-26
3-27
3-29
3-30
3-31
3-33
3-37
3-41
3-43
3-45
3-46
3-48
3-51
3-53
3-55
3-56
3-58
3-59
3-60
3-61
3-63
3-67
3-68
3-69
3-8.
General.
Since most shelters contain sensitive electronic equipment that cannot be
easily removed, unit level maintenance and repair will primarily involve shelter exteriors or
easily accessible interior areas, unless floors, ceilings or walls have evidence of water intrusion
which can jeopardize operation of the equipment. The shelter shall be returned to the depot
for repair if any of the following conditions exist:
a .
Panel damages pans a structural member.
b .
Replacement of an entire wall, ceiling, or
c .
Extensive equipment removal beyond the
d .
Welding is required.
e .
Damage to a structural member is severe
especially in edge or corner areas.
floor is required.
capability of the using unit is required.
enough to cause distortion of a wall,
f .
Lift, tow, or tiedown fittings or corner castings are damaged severely enough to
indicate possible damage to the underlying structural member.
3-11
Back to Top
