TM-9-2330-227-14-P

SEMITRAILER, VAN: SHOP, 6-TON, SINGLE AXLE, M146

TECHNICAL MANUAL; OPERATOR’S, ORGANIZATIONAL, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)

JUNE 1985

TM-9-2330-227-14-P - Page 349 of 576

TM 9-2330-227-14&P

Section IX. BODY

Page

Body Repair . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-97

Deck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . 5-91

SIDE DOOR AND RIGHT REAR DOOR

MAINTENANCE

Page

Left Rear Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-84

Side Door and Right Rear Door . . . . . . . . . . . . . . . . . 5-75

This task covers:

Repair (page 5-75)

INITIAL SETUP

Tools

Brush, wire

Hammer, ball-peen, machinist’s, l-lb

Handle, ratchet, l/2-inch drive

Pliers, long round-nose

Punch, drive-pin, l/16-inch

Punch, drive-pin, l/8-inch

Punch, drive-pin, 3/16-inch

Screwdriver, cross-tip, number two

Screwdriver, flat-tip, 3/16-inch

Socket, l/2-inch drive, l/2-inch

Wrench, open-end, l/2-inch

Materials/Parts

Adhesive (item 1, appendix E)

Rivets, blind (as required)

Personnel Required

One

Equipment Condition

Side door removed if being repaired

(page 4-166).

Right rear door removed if being repaired

(page 4-166).

ACTION

LOCATION

ITEM

REMARKS

REPAIR

NOTE

The procedure for repairing the side door and right rear door is the same except for the

exterior handles. Any differences will be so noted in the procedure.

Disregard any difference in the number of panel rivets used on your doors as compared

to the number shown in this procedure. This may vary.

5-75