TM-9-2330-356-14
SEMITRAILER, TANK: 5000 GALLON, BULK HAUL, SELF LOAD/UNLOAD M967 AND M967A1; SEMITRAILER, TANK: 5000 GALLON, FUEL DISPENSING, AUTOMOTIVE M969 AND M969A1; SEMITRAILER, TANK: 5000 GALLON, FUEL DISPENSING, UNDER/OVERWING AIRCRAFT M970 AND M970A1
TECHNICAL MANUAL; OPERATOR’S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL
OCTOBER 1990
TM-9-2330-356-14 - Page 288 of 528
TM 9-2330-356-14
TA099873
Figure 4-143. 45° Elbow and Breakaway Fitting
Replacement.
(d)
Attach 45° elbow and breakaway fitting
half to new hose.
(e)
Assemble breakaway fitting (para 3-13).
(f)
Loosen hose reel lock and rewind hose
(para 2-11).
(g)
Install underwiring nozzle onto hose
(para 3-17).
c.
Replacement of Hose on Deadman Hose Reel (M970
and M970A1).
(1)
Removal.
(a)
Pull hose reel out far enough to remove
deadman control from hoses.
(b)
Remove the two screws and nuts on the
deadman control to free the valve assembly (fig. 4-145).
(c)
Disconnect the two hoses from the valve
assembly.
(d)
Remove the hose ball stop from hose by
removing the two screws securing the two halves together.
NOTE
Do not unwind hose reel fully. Hose reel may
not release to rewind.
(e)
Pull remaining hoses from hose reel.
Make sure you can reach the ends of the hoses.
WARNING
With hose pulled from hose reel, the reel is
under spring tension. Be careful not to
release hose reel when removing hoses.
Personal injury could result.
(f)
Disconnect hoses from elbows on the
hose reel and remove (fig. 4-144).
TA099874
Figure 4-144. Installation of Hoses to Deadman
Hose Reel.
(2)
Installation.
(a)
Thread red hose through opening in
handle guard (fig. 4-145) and attach to OUT port of valve
assembly. Attach green hose to IN port of valve assembly.
(b)
Replace valve assembly in handle guard
of deadman control. Secure with two screws and nuts.
(c)
On green hose, replace the hose ball
stop about 12-inches from the deadman control.
(d)
Thread the two hoses through opening
in hose roller assembly (fig. 4-144).
(e)
Attach green hose to outside elbow
(fig. 4-144) on hose reel and attach red hose to inside
elbow.
(f)
Pull hoses to release latch on hose reel
and rewind the hoses.
4-152
Back to Top
