TM-5-2350-377-14-P
ARMORED COMBAT EARTHMOVER (ACE), M9
TECHNICAL MANUAL; OPERATOR'S, UNIT, DIRECT SUPPORT, AND GENERAL SUPPORT MAINTENANCE MANUAL (INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST) SUPPORTING THE HYDRAULIC BLADE FOLDER-TRACK TENSIONER (HBF-TT)
TM-5-2350-377-14-P - Page 126 of 335
TM 5-2350-377-14&P
DISASSEMBLY
WARNING
Cleaning solvent (PF05) is combustible.
Wear protective goggles and gloves; use only
in a well-ventilated area; avoid contact with skin, eyes, and clothes; and do not breathe
vapors.
Keep away from heat or flame.
Never smoke when using cleaning solvent; the
flashpoint is 144°F (62°C).
Failure to follow this warning may result in injury or death to
personnel.
If personnel become dizzy while using cleaning solvent, immediately get fresh air and
medical help.
If solvent contacts skin or clothes, flush with cold water.
If solvent contacts
eyes, immediately flush them with water and get immediate medical attention.
When PF05 cleaning solvent is used, notify the local medical authority (preventive
medicine) and environmental coordinator concerning medical surveillance, respiratory
protection, and disposal requirements.
NOTE
Use this task to replace left or right support.
Right support is shown.
Steps 1 through 5, Disassembly, apply to Figure 13.
1. Remove jamnut (item 9) from receptacle connector (item
2) and support (item
8).
Figure 13.
Headlight Support.
0021 00
HEADLIGHT SUPPORT REPLACEMENT
0021 00-1
INITIAL SETUP
Tools/Test Equipment
Tool kit, general mechanic's
(Item 6, WP 0056 00)
Chemical and oil protective gloves
(Item 12, WP 0055 00)
Industrial goggles (Item 13, WP 0055 00)
Wire brush (Item 5, WP 0055 00)
Acid swabbing brush (Item 4, WP 0055 00)
Materials/Parts:
Sealant adhesive
(Item 1, WP 0055 00)
Equipment Conditions
Front of vehicle blocked
(TM 5-2350-262-20-1)
Hydraulic pressure relieved (TM 5-2350-262-20-1)
Negative battery cables disconnected
(TM 5-2350-262-20-1)
Cleaning solvent (Item 7, WP 0055 00)
Wiping rag (Item 17, WP 0055 00)
Gasket (Item 26, WP 0048 00, Figure 10)
Lockwasher (Item 24, WP 0048 00, Figure 10)
6
5
7
8
3
2
1
9
4
Back to Top
