TM-9-2815-210-34-2-2
ENGINE ASSEMBLY, DIESEL (MULTIFUEL): NATURALLY ASPIRATED OR TURBOCHARGED, FUEL-INJECTED, WATER-COOLED, 6-CYLINDER
TECHNICAL MANUAL; TROUBLESHOOTING; DIRECT SUPPORT AND GENERAL SUPPORT LEVEL; VOLUME 2 OF 2; PART 2 OF 2
APRIL 1981
TM-9-2815-210-34-2-2 - Page 32 of 968
TM 9-2815-210-34-2-2
FRAME 4
CAUTION
1.
2.
3.
4.
Be careful not to nick or scratch journals on crank-
shaft (1).
If crankshaft journals are damaged, engine
will not run properly.
Take out crankshaft gear woodruff key (2).
WARNING
Dry cleaning solvent is flammable. Do not use near
an open flame.
Keep a fire extinguisher nearby when
solvent is used.
Use only in well-ventilated places.
Failure to do this may result in injury to personnel
and damage to equipment.
Clean crankshaft (1) with dry cleaning solvent. Clean off sludge and gum
using stiff brush.
Dry with clean cloth.
WARNING
Eye shields must be worn when using compressed air.
Eye injury can occur if eye shields are not used.
Using fuel passage cleaning brush, clean oil passages in crankshaft (1).
Flush passages with dry cleaning solvent and blow dry with compressed air.
Put crankshaft gear woodruff key (2) back in crankshaft (1) so it will not
be lost.
GO TO FRAME 5
4-13
Back to Top
